Water Heater Leaking From Control Panel

Turn off the power the heating element will sit in the control panel of the water heater and this panel typically sits underneath a metal cover.

Water heater leaking from control panel.

A leaking water heater has the potential to become dangerous if the leak is coming from the pressure relief valve. Keep reading to find out how to resolve the leak issue. This will allow air to enter the tank. If it s an electric water heater.

Generally when water leaks from this location it could mean that the tank is under extra pressure and by leaking water it is trying to release some of that pressure. Remove the access door s and insulation pad s. If it s a gas water heater it will have a dial or an on off switch near the spot where the gas line connects. 7 using control panel 6 to switch on off the heater.

While switched on the. You ll have to drain the tank for that fix too. Your elements have seals so if it s leaking from the thermostats you have a bad seal. If you have a plastic drain valve your best bet is to replace the entire valve.

Drain the hot water tank. Turn off the power to the leaking water heater. Repairing a water heater leaking from the drain valve is a fairly easy but time consuming fix because you have to shut off the water and drain the tank. Both thermostats should be set the same to spec of 120degrees which will say on upper and lower when panels are.

By water leaking from the water heater pressure relief valve a circuit breaker or fuse block in the service panel or a turn the electrical supply to the water heater off. Open the hot water taps until the water is not hot any more. It s not necessary to drain it completely only so that the water inside the tank is lower. A leak in the drain valve at the bottom of the water heater is another common issue.

This drain valve can be capped with a hose cap or you can replace the drain valve completely with a new valve. If your water heater is leaking water near the control panel of the device then the device is likely leaking fluid around the heating element. Use a wrench to grab hold of the t p valve and turn it counter clockwise until the valve is loose. Switch off the electric supply to the water heater.